Jul, 04 2019 14:20 JST

Source: Toyota Motor Corporation

NEDO, Sharp, and Toyota to Begin Public Road Trials of Electrified Vehicles Equipped with High-efficiency Solar Batteries

Testing the potential of solar batteries toward CO2 emissions reductions in the transport sector

TOKYO, Jul, 04 2019 - (JCN Newswire) - NEDO, Sharp Corporation (Sharp), and Toyota Motor Corporation (Toyota) plan to commence public road trials from late July 2019. The trials aim to assess the effectiveness of improvements in cruising range and fuel efficiency of electrified vehicles equipped with high-efficiency solar batteries.

Figure 1: Prius PHV demo model equipped with solar battery panel
 

Figure 2: Solar battery panel consisting of several solar battery cells (rear hatch door portion)
 


To facilitate the execution of this trial, Sharp modularized its world-class, high-efficiency solar battery cells(1) (conversion efficiency of 34%+(2)), previously developed for a NEDO-led project(3), to create an onboard solar battery panel. Toyota installed this panel on the roof, hood, rear hatch door, and other parts of its "Prius PHV" and produced a demo car for public road trials. By enhancing the solar battery panel's efficiency and expanding its onboard area, Toyota was able to achieve a rated power generation output of around 860 W(4), which is approximately 4.8-times higher in comparison with the commercial model Prius PHV (equipped with a solar charging system). In addition to substantially boosting its power generation output, the demo car employs a system that charges the driving battery while the vehicle is parked and also while it's being driven, a development that is expected to lead to considerable improvements in electric-powered cruising range and fuel efficiency.

Toyota plans to conduct the trials under various driving conditions in Toyota City, Aichi Prefecture, Tokyo, and other areas. Various data, including the power generation output of the solar battery panel and the amount the drive battery is charged, will be obtained and verified, and then used in the development of an onboard solar recharging system. Toyota plans to share a selection of trial data results with NEDO and Sharp. The PV-powered Vehicle Strategy Committee(5) (PV: photovoltaic), sponsored by NEDO and other entities will evaluate the benefits based on improvements in CO2 emissions reductions and convenience, such as the number of times a vehicle requires recharging. The goal is to contribute to the creation of a new solar battery panel market, including the transport sector, and find solutions for energy and environmental issues.

Figure 1: Prius PHV demo model equipped with solar battery panel
http://www.acnnewswire.com/topimg/Low_NEDOSharpToyota1%20.jpg

Background

In April 2016, NEDO, a national research and development organization, set up the PV-powered Vehicle Strategy Committee, which is comprised of members from industry and academia. With the goal of finding solutions to energy and environmental issues in the transport sector, the committee's research focuses on solar power systems. Sharp and Toyota are also active committee participants. The achievements the committee has made thus far include estimates(6) on the potential to achieve an output of 1 kW in vehicles, despite the limited space for installing power systems, by using a solar battery module with a conversion efficiency of 30 percent-plus, zero annual recharging depending on usage patterns, and estimated benefits from a reduction in CO2 emissions.

Profile of demo car

The demo car is equipped with a solar battery panel that utilizes several solar battery cells with a conversion efficiency of 34 percent-plus. The shape of the module, environmental durability, surface materials, and other factors are based on specifications for driving trials implemented by Toyota. The solar battery cell is a thin film about 0.03 mm in thickness. This makes it possible to efficiently install the film to fit the curves of parts with limited space, including the vehicle roof, hood, and rear hatch door. The rated power generation output of the demo car is approximately 860 W.

Previously, the Prius PHV charged the driving battery only while the vehicle was parked. However, with improvements in power generation output, the demo car employs a system that charges while the vehicle is being driven. This is expected to boost the BEV-mode cruising range and fuel efficiency significantly.

Figure 2: Solar battery panel consisting of several solar battery cells (rear hatch door portion)
http://www.acnnewswire.com/topimg/Low_NEDOSharpToyota2%20.jpg

Trial Timeline

Toyota plans to share a selection of trial data results with NEDO and Sharp. The PV-powered Vehicle Strategy Committee and other entities will evaluate the benefits from improvement in the reduction of CO2 emissions and the improvement in convenience, including the number of times a vehicle requires charging. The goal is to further contribute to the creation of a new solar battery panel market, including the transport sector, and find solutions for energy and environmental issues.

- 1) High-efficiency solar battery cell :
Development of the above cell was carried out by a NEDO-led project. Applications were envisaged for the power generation business to achieve a cost of YEN7/kWh. The project aims to focus on the high conversion efficiency rate and verification of its potential for use in vehicles.
https://www.nedo.go.jp/english/news/AA5en_100070.html
- 2) Conversion efficiency of 34%+ :
Calculated based on cell output (as measured by Sharp) under AM1.5 G standard solar battery test conditions as stipulated by international standards.
- 3) NEDO project :
Project Development of high performance and reliable PV modules to reduce levelized cost of energy; research and development of innovative new structure solar cells; research and development of ultra-high efficiency and low-cost III-V compound semiconductor solar cell modules Period FY 2016 to 2020
- 4) Approximately 860 W :
Total module output based on calculation of cell output (as measured by Sharp).
- 5) PV-powered Vehicle Strategy Committee :
Established by NEDO in April 2016 to conduct research and investigate automotive photovoltaic systems with the goal of further contributing to finding solutions for energy and environmental issues and to create new markets.
- 6) Estimates :
Examined the (1) benefits of CO2 emissions reduction, (2) user convenience (number of times the vehicle requires charging), and (3) benefits of CO2 emissions reduction to society at large when the use of PV-powered vehicles is wide spread. The results were published in an interim report released in January 2018. (https://www.nedo.go.jp/english/news/AA5en_100358.html)


About Toyota Motor Corporation
Toyota Motor Corporation (TMC) is the global mobility company that introduced the Prius hybrid-electric car in 1997 and the first mass-produced fuel cell sedan, Mirai, in 2014. Headquartered in Toyota City, Japan, Toyota has been making cars since 1937. Today, Toyota proudly employs 370,000 employees in communities around the world. Together, they build around 10 million vehicles per year in 29 countries, from mainstream cars and premium vehicles to mini-vehicles and commercial trucks, and sell them in more than 170 countries under the brands Toyota, Lexus, Daihatsu and Hino. For more information, please visit www.toyota-global.com.


Contact:
Public Affairs Division
Global Communications Department
Toyota Motor Corporation
Tel: +81-3-3817-9926
Source: Toyota Motor Corporation
Sectors: Automotive, Environment, Alt. Energy, IoT, Transport

Copyright ©2019 JCN Newswire. All rights reserved. A division of Japan Corporate News Network.

Related Press Release


Toyota Rolls Out Completely Redesigned Corolla, Corolla Touring, and Unveils Improvements to the Corolla Sport in Japan
September 17 2019 12:16 JST
 
A Power Stage Win and Crucial Points for TOYOTA GAZOO Racing
September 17 2019 08:10 JST
 
Silverstone One-Two for TOYOTA GAZOO Racing
September 02 2019 16:39 JST
 
Toyota Releases Sales, Production, and Export Results
August 29 2019 15:09 JST
 
Toyota and Suzuki Enter into Capital Alliance Agreement
August 29 2019 11:59 JST
 
Toyota Yaris WRC Sweeps the Podium in Germany
August 26 2019 08:15 JST
 
Toyota Provides Diverse Mobility for Tokyo 2020, including a Full Line-up of Electrified Vehicles
August 23 2019 15:58 JST
 
Fernando Alonso Keeps an Eye on Dakar with TOYOTA GAZOO Racing
August 20 2019 16:06 JST
 
Toyota Yaris WRC Ready to Master the Varied Roads of Germany
August 16 2019 19:13 JST
 
Toyota and Preferred Networks to Begin Joint Development on Service Robots that Cater to Market Needs
August 07 2019 14:03 JST
 
More Press release >>

Latest Press Release


More Latest Release >>