How to get the most fuel out of microalgae?
Direct electrolysis has mixed results for extracting fuel sources from microalgae.
SELANGOR, Malaysia, Dec 14, 2018 - (ACN Newswire) - Researchers are investigating ways to improve biodiesel production by using electrical fields to break open microalgae cells, with varied results, according to a new study in the Pertanika Journal of Science & Technology.
| Researchers are investigating ways to improve lipid extraction from microalgae to make biofuels. (Copyright: 123rf/Akhararat Wathanasing) |
Lipids inside microalgae are a promising source of biofuel. Microalgae cells must first be broken apart in order to extract the lipids. Conventional technologies are energy intensive and time consuming, so a group of researchers from Universiti Malaysia Sabah investigated a novel method using direct electrolysis.
During electrolysis, cells are disrupted when electric field forces overcome the interactions which hold membranes together, resulting in the formation of pores in the cell membrane. In this study, the researchers passed the microalga Chlorella sp. through electric fields of different strengths generated by two stainless steel electrodes. Electrolyzed cells were subsequently freeze-dried and treated with solvents to extract lipids.
The amount of lipids extracted from cells that passed through low electric fields was the same as cells that did not go through electrolysis. In contrast, at high electric fields, 11% to 13% fewer lipids were extracted from electrolyzed cells than the untreated cells. The researchers hypothesized that the lipids may have been lost through oxidation during electrolysis.
The researchers also investigated if solvents are required for lipid extraction of electrolyzed cells. Their analysis found that lipids were present only in the solvent extract, indicating that lipids cannot be extracted by electrolysis alone.
Methyl palmitate - a fatty acid preferred for use in biodiesel engines, and methyl linolenate were the major components in the extracted lipid, with no significant difference in methyl palmitate concentration of electrolyzed and untreated samples. The researchers also observed that no intact cells remained after electrolysis. The findings indicate that while the direct electrolysis treatment was effective at disrupting microalgal cells, it did not significantly enhance lipid extraction efficiency.
For the method to achieve the higher lipid yields reported in literature and be feasible for microalgal lipid extraction in biodiesel production, parameters such as field strength and solvent type should be optimized. Further investigation into the effect of oxidation on lipid loss is also required.
For more information about this research, please contact:
Assoc. Prof. Dr Rachel Fran Mansa Head of Energy and Materials Research Group Materials and Minerals Research Unit The Faculty of Engineering Universiti Malaysia Sabah Jalan UMS, 88400, Kota Kinabalu Sabah, Malaysia Email: rfmansa@ums.edu.my Tel: +6088 320 000 Ext 1543
About Pertanika Journal of Science & Technology (JST)
Pertanika Journal of Science & Technology (JST) is published by Universiti Putra Malaysia in English and is open to authors around the world regardless of nationality. Currently, it is published four times a year in January, April, July and October. Other Pertanika series include Pertanika Journal of Tropical Agricultural Science (JTAS), and Pertanika Journal of Social Sciences & Humanities (JSSH).
Pertanika Journal of Science & Technology aims to provide a forum for high quality research related to science and engineering research. Areas relevant to the scope of the journal include: bioinformatics, bioscience, biotechnology and bio-molecular sciences, chemistry, computer science, ecology, engineering, engineering design, environmental control and management, mathematics and statistics, medicine and health sciences, nanotechnology, physics, safety and emergency management, and related fields of study. Visit: http://www.pertanika.upm.edu.my/
The paper is available from this link: https://bit.ly/2QwrBMs
For more information about the journal, contact:
The Chief Executive Editor (UPM Journals) Pertanika Journal Office of the Deputy Vice Chancellor (R&I) Tower II, UPM-MDTC, Putra Science Park Universiti Putra Malaysia 43400 Serdang, Selangor Darul Ehsan MALAYSIA Phone: +603 8947 1622 Email: executive_editor.pertanika@upm.my
Press release distributed by ResearchSEA for Pertanika Journal.
Source: Pertanika Journal Sectors: Science & Nanotech, Environment, ESG, Alternative Energy, BioTech
Copyright ©2024 ACN Newswire. All rights reserved. A division of Asia Corporate News Network.
|
Latest Release
Mitsubishi Shipbuilding Receives Order from the University of Tokyo for "MiPoLin" Power Prediction and Lines Selection System Mar 28, 2024 16:45 JST
| Mitsubishi Logisnext Completes Demonstration of Automated Truck Loading, Leading to Start of Actual Operations in Japan Mar 28, 2024 13:52 JST
| Toyota Releases Sales, Production, and Export Results for February 2024 Mar 28, 2024 13:35 JST
| TANAKA to Install 500 kW Fuel Cell System to Promote the Use of Hydrogen Energy at Production Plants Mar 28, 2024 03:00 JST
| PEVE to change name to TOYOTA BATTERY Co., Ltd. and produce batteries for a wide range of electric vehicles Mar 27, 2024 15:13 JST
| NTT and Olympus Begin World's First Joint Demonstration Experiment of Cloud Endoscopy System Mar 27, 2024 15:00 JST
| TANAKA Holdings Announces Green Loan Financing for Construction of New Head Office Building Mar 27, 2024 03:00 JST
| JFE Steel and Hitachi Jointly Started Providing Solutions for the Steel Industry Mar 26, 2024 19:04 JST
| La Banque Postale and JCB join forces to elevate payments experience for travellers in France Mar 26, 2024 15:00 JST
| Fujitsu Tech Leverages AI and Underwater Drone Data for 'Ocean Digital Twin' Mar 26, 2024 10:24 JST
| NEC develops marketing strategy planning & effectiveness simulation technology using generative AI Mar 25, 2024 10:08 JST
| Toyota to Open New Tokyo Head Office in Shinagawa in FY2030 Mar 22, 2024 16:15 JST
| Hitachi Selected as CDP Supplier Engagement Leader for the Third Consecutive Year Mar 22, 2024 16:04 JST
| Mitsubishi Motors Celebrates Production of 100,000th fully electric minivehicle Mar 22, 2024 15:34 JST
| JCB and AEON Credit Service Indonesia Launch the AEON JCB Precious Card Mar 22, 2024 15:00 JST
| JCB Issues White Paper on Calculating CO2 Emissions by Payment Method in Japan Mar 22, 2024 12:00 JST
| NEC and NTT successfully conduct first-of-its-kind long-distance transmission experiment over 7,000km using 12-core optical fiber Mar 22, 2024 08:38 JST
| Lifenet and Eisai Co-Develop Dementia Insurance "be" Mar 21, 2024 17:36 JST
| Toyota: Clarification of the Roles of and Expectations for Outside Executives, Revision of the Independence Assessment Criteria, and the Changes to Members of the Board of Directors and the Audit and Supervisory Board Members following the 120th Ordinary General Shareholders' Meeting Mar 21, 2024 16:47 JST
| Sales of Evolved GR Yaris to Start in April, While Purchasing Lotteries for WRC Driver-supervised Special Editions Start Today Mar 21, 2024 16:31 JST
|
More Latest Release >>
|